Volume 8, Issue 1, January 2020, Page: 17-21
Experimental Investigation of Pipeline Corrosion in a Polluted Niger Delta River
Odutola Toyin Olabisi, Department of Petroleum and Gas Engineering, University of Port Harcourt, Choba, Nigeria
Amobi Chukwuka, Department of Petroleum and Gas Engineering, University of Port Harcourt, Choba, Nigeria
Received: Dec. 16, 2019;       Accepted: Jan. 9, 2020;       Published: Jan. 21, 2020
DOI: 10.11648/j.ogce.20200801.13      View  287      Downloads  122
Several networks of pipelines in Nigeria oil and gas industry have failed catastrophically in the last two decades because most oil pipelines operate in a corrosive environment and transport corrosive fluids. This research experimentally investigates the corrosion of a carbon steel pipeline immersed in a typical Niger Delta Offshore Environment. The experiment was carried out using the gravimetric (weight loss) method. The carbon steel coupon was immersed in a sample of water collected from the Niger Delta sea and in seawater polluted by 0.5mol/dm3, 1.0mol/dm3, 1.5mol/dm3 and 2.0mol/dm3 tetraoxosulphate (VI) acid respectively. The coupons were retrieved and examined at 4-hour interval. It was discovered that in an unpolluted state, the seawater was not corrosive. However, when polluted by 0.5mol/dm3, 1.0mol/dm3, 1.5mol/dm3 and 2.0mol/dm3 tetraoxosulphate (VI) acid, corrosion occurred. The highest rate of corrosion was observed in the coupon dipped into the seawater sample polluted by 2.0mol/dm3 of tetraoxosulphate (vi) acid and the lowest corrosion rate observed in the least polluted seawater 0.5mol/dm3. Corrosion rate increased with increasing pollutants; therefore, it is imperative for oil operators to carefully dispose of their waste to prevent rapid corrosion of subsea pipelines and other offshore facilities.
Corrosion, Niger Delta, Carbon Steel Pipes, Pollution
To cite this article
Odutola Toyin Olabisi, Amobi Chukwuka, Experimental Investigation of Pipeline Corrosion in a Polluted Niger Delta River, International Journal of Oil, Gas and Coal Engineering. Vol. 8, No. 1, 2020, pp. 17-21. doi: 10.11648/j.ogce.20200801.13
Copyright © 2020 Authors retain the copyright of this article.
This article is an open access article distributed under the Creative Commons Attribution License (http://creativecommons.org/licenses/by/4.0/) which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.
Ozumba, U. I., (1997),” Sabotage and corrosion spills in SPDC-W, 1987-1996’’, Vol 13 no 1: 3-49.
Umezurike, C (1999), Combating Oil Spillage with Chemical Dispersants. NICA. Proc. of 2nd Int'l Corr. Conf. Abuja, Nigeria
Eker B. and Yuksel E. (2005): Solutions to Corrosion Caused by Agricultural Chemicals, Trakia Journal of Sciences, Vol. 3, No. 7, pp 1-6.
Umoren S. A. (2009): Polymers as Corrosion Inhibitors for Metals in Different Media – A Review, The Open Corrosion Journal, 2009, 2, 175-188, pp 175-188
Nwilo, P. C and Badejo, O. T., (2001),’’Impact of oil spills along the Nigeria coast” (International Journal of Environmental Health). Vol 04.
Okiongbo, K. (2013). Predicting Soil Corrosivity along a Pipeline Route in the Niger Delta Basin Using Geoelectrical Method: Implications for Corrosion Control. Engineering. 05. 237-244. 10.4236/eng.2013.53034.
Hedborg C. E. (1974): “Corrosion in the Offshore Environment” paper OTC-1958-MS presented at sixth Annual Offshore Technology Conference held in Houston, Texas, May 6-8, 1974.
Speight J. G.(2011): Chapter 8- Corrosion in Subsea and Deepwater Oil and Gas Technology, pages 213-256, Gulf Professional Publishing
George V. C., Ryan M., and Ghazi D. A., in The Fundamentals of Corrosion and Scaling for Petroleum & Environmental Engineers, 2009, Gulf Publishing Company
Richard W. Drisko and James F. Jenkins (2005) “Good Painting Practice: SSPC Painting Manual” Volume 1, Fourth Edition, SSPC: The Society for Protective Coatings, Pp: 29-39
Uko, E. D., Benjamin F. S. and Tamunobereton-ari, I. “Characteristics Of Soil For Underground Pipeline Laying In The Southwest Niger Delta”, vol 04, page 5, 2014.
Kjellerup, B. V.; G. Gudmonsson, K. Sowers and P. H. Nielsen., (2006). Evaluation of Analytical Method for Determining the Distribution of Biofilm and Active Bacteria in a Commercial Heating System, Journal of Biofouling, vol 22: 133–139.
Devesh P. K., Akshay P. S. and Himanshukumar R. P. (2018): IOSR Journal of Electrical and Electronics Engineering (IOSR-JEEE), Volume 13, Issue 2 Ver. I (Mar. – Apr. 2018), PP 85-93.
Anyanwu, S. I., Nwosu, H. U., Reginald, A. E., Eseonu, O., (2014).”Correlation between soil properties and external corrosion growth rate of carbon steel (international Journal of Engineering and science), vol, page no 38-47.
Chinwko, E. C., Odio, B. O., Chukwuneke, J. L., Sinebe, J. E., (2014), “Investigation of the effect of corrosion on mild steel in five different environments”, international journal scientific and technology research, vol 3, issue 7, July 2014.
Browse journals by subject